RTO廣泛應用于石油及化工(如塑料、橡膠、合成纖維、有機化工) ; 油漆生產及噴漆;印刷(包括印鐵、印紙、印塑料);電子元件及電線;農藥及染料，醫藥;顯像管、膠片、磁帶等。烷烴、烯烴、醇類、酮類、醚類、脂類、芳烴、苯類等碳氫化合物有機廢氣;有機物低濃度 (同時滿足低于25%LEL)、大風量;廢氣中含有多種有機成分、或有機成分經常發生變化;含有容易使催化劑中毒或活性衰退成分的廢氣。

RTO is widely used in petroleum and chemical industries (such as plastics, rubber, synthetic fibers, organic chemicals); Paint production and painting; Printing (including printing iron, printing paper, printing plastic); Electronic components and wires; Pesticides and dyes, pharmaceuticals; CRT, film, magnetic tape, etc. Organic waste gases containing hydrocarbons such as alkanes, olefins, alcohols, ketones, ethers, lipids, aromatics, and benzene; Low concentration of organic matter (while meeting the requirement of less than 25% LEL) and high air volume; The exhaust gas contains multiple organic components, or the organic components often change; Waste gas containing components that can easily cause catalyst poisoning or activity decline.

技術特點

Technical characteristics

操作費用低，超低燃料費;

Low operating costs and ultra-low fuel costs;

有機廢氣濃度在450ppm以上時，RTO裝置不需要添加輔助燃料凈化率高;

When the concentration of organic waste gas is above 450ppm, the RTO device does not need to add auxiliary fuel for high purification rate;

不產生氮氧化物等二次污染

No secondary pollution such as nitrogen oxides generated

全自動控制、操作簡單;

Fully automatic control, simple operation;

安全性高，使用壽命長，維護保養簡單:

High safety, long service life, and simple maintenance:

1、包裝行業

1. Packaging industry

包裝印刷行業在生產過程中適用大量的溶劑型油墨，而這些溶劑型油墨含有50%-60%的揮發性組分，加上調整油墨粘度所需的稀釋劑，在印刷品的生產和干燥過程中會排放大量的VOC有機廢氣，其中主要成分為苯、甲苯、二甲苯、非甲烷總烴等。

The packaging and printing industry uses a large amount of solvent based inks in the production process, which contain 50% -60% volatile components. In addition, diluents required to adjust ink viscosity will emit a large amount of VOC organic waste gas in the production and drying process of printed materials, including benzene, toluene, xylene, and non-methane total hydrocarbons.

包裝行業場景

Packaging Industry Scenarios

2、化工行業

2. Chemical industry

化工廠產生的廢氣通常大致分為三類：

The exhaust gases generated by chemical plants are generally divided into three categories:

1、含硫的化合物，如硫化氫、硫醇類、二甲基硫、硫醚類及含硫的雜環化合物等；

1. Sulfur-containing compounds, such as hydrogen sulfide, thiols, dimethyl sulfur, thioethers, and sulfur-containing heterocyclic compounds;

2、含氮的化合物，如氨、胺類、腈類、硝基化合物及含氮雜環化合物等

2. Nitrogen containing compounds, such as ammonia, amines, nitriles, nitro compounds, and nitrogen-containing heterocyclic compounds

3、碳、氫或碳、氫、氧組成的化合物（低級醇、醛、脂肪酸等）。

3. Compounds composed of carbon, hydrogen, or carbon, hydrogen, oxygen (lower alcohols, aldehydes, fatty acids, etc.).

化工廢氣特點：

Characteristics of chemical waste gas:

1、易燃、易爆氣體較多。

1. There are many flammable and explosive gases.

如低沸點的酮、醛、易聚合的不飽和烴等，大量易燃、易爆氣體如不采取適當措施，容易引起火災、爆炸事故，危害極大。

Low boiling ketones, aldehydes, easily polymerizable unsaturated hydrocarbons, and a large amount of flammable and explosive gases can easily cause fire and explosion accidents if appropriate measures are not taken, posing great harm.

2、排放物大多都有刺激性或腐蝕性。

2. Most emissions are irritant or corrosive.

如二氧化硫、氮氧化物、氯氣、氟化氫等氣體都有刺激性或腐蝕性，尤其以二氧化硫排放量最大，二氧化硫氣體直接損害人體健康，腐蝕金屬、建筑物和雕塑的表面，還易氧化成硫酸鹽降落到地面，污染土壤、森林、河流、湖泊。

Gases such as sulfur dioxide, nitrogen oxides, chlorine gas, and hydrogen fluoride all have irritant or corrosive properties, with sulfur dioxide emissions being the highest. Sulfur dioxide directly harms human health, corrodes the surfaces of metals, buildings, and sculptures, and is also prone to oxidation into sulfates that fall to the ground, polluting soil, forests, rivers, and lakes.

3、廢氣中浮游粒子種類多、危害大。

3. There are many types of floating particles in the exhaust gas, which are highly harmful.

化工生產排除的浮游粒子包括粉塵、煙氣、酸霧等，種類繁多，對環境的危害較大。特別當浮游粒子與有害氣體同時存在時能產生協同作用，對人的危害更為嚴重。

The suspended particles discharged from chemical production include dust, smoke, acid mist, etc., with a wide variety of types and significant environmental hazards. Especially when planktonic particles and harmful gases coexist, they can have a synergistic effect and pose a more serious threat to humans.

化工行業場景

Scenarios in the chemical industry

3、造紙行業

3. Paper industry

造紙廠廢氣成分主要是：苯、甲苯、二甲苯、丙酮、乙酸乙酯、環己酮、醇類等，如果不處理會對工人、周邊居民和環境造成一定影響。

The main components of waste gas from paper mills are benzene, toluene, xylene, acetone, ethyl acetate, cyclohexanone, alcohols, etc. If not treated, it will have a certain impact on workers, surrounding residents, and the environment.

造紙行業應用場景

Application scenarios in the papermaking industry

本文由沸石轉輪＋CO友情奉獻.更多有關的知識請點擊:http://m.azsolar.cc真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

This article is dedicated by zeolite wheel+CO friendship. For more information, please click: http://m.azsolar.cc Sincere attitude. We will provide you with comprehensive service. We will gradually contribute more relevant knowledge to everyone. Stay tuned